Whether you're heading off on a long road trip or just fighting city traffic and the odd gravel road on weekends, knowing the main replaceable parts on your HAVAL H9 can save you a heap of hassle.

The H9 is a real body-on-frame SUV—not one of those soft crossovers people only drive to pick up coffee. Under the panels, you’ll find a surprising number of structural, exterior, and engine-bay components that take the brunt of heat, dust, and vibration. Most of them last a long time, but when they finally wear out, they don’t usually fail quietly.

Below is a practical breakdown of the major HAVAL H9 components people most often replace—fully aligned with the actual parts found in the H9 catalog.

Engine Bay Components

Even though the engine itself is built tough, the surrounding hardware in the engine bay deals with heat, airflow, and constant vibration. These parts affect cooling efficiency, noise levels, and general reliability.

Key replaceable parts (from actual catalog)

1. Radiator ASSY
2. Intercooler ASSY
3. Condenser ASSY
4. Radiator Fan ASSY
5. Radiator frame / support assemblies
6. Engine Hood ASSY (bonnet)
7. Engine hood hinges (LH/RH)
8. Engine hood lock + latch assemblies
9. Engine compartment covers and connectors
10. Lower guard boards under the engine and front reductor
11. Air deflectors & cooling guides

Real-world signs these parts need attention

A tired radiator fan sounds louder than usual—almost like it’s working overtime.
A bent guard board under the engine can rattle on rough roads.
A worn hood latch may make the hood sit unevenly or require extra force to close.
Dust-heavy off-road use often clogs the condenser and intercooler fins, hurting cooling efficiency.

Typical service considerations

1. Intercooler & condenser fins: clean every off-road season
2. Guard board: inspect after any underbody hit
3. Hood hinges & latch: lubricate periodically
4. Radiator mounting frame: check alignment after front impacts

Transmission & Underbody Protection

While the internal transmission isn’t part of the provided catalog, the underbody hardware that protects it is.

Replaceable parts from catalog

1. Guard board – transmission lower
2. Guard board – engine lower
3. Guard board – front reductor lower
4. Crossmember-related protection plates

These components shield the drivetrain during off-road driving. A slightly bent plate can reduce ground clearance more than drivers realize.

Braking System (Exterior-Related Components)

The catalog does not include discs or pads, but it does include several exterior components that integrate with brake zones, such as wheel-area splash shields and wheelhouse assemblies.

Relevant catalog parts

1. Wheelhouse assemblies (FR / RR, LH / RH)
2. Splash shield assemblies
3. Dashboards inside the wheel arches

These keep mud, water, and stones away from brake components, helping them last longer.

Suspension & Chassis Components

The main suspension arms and shocks aren’t in the catalog, but several structural chassis parts are.

Replaceable items

1. Trailing arm assemblies (RR LH/RH)
2. Stabilizer RR & stabilizer connecting rods
3. Underbody shields and brackets

A loose stabilizer rod can cause clunks on uneven roads. Trail arms see wear when carrying heavy loads or driving on corrugated gravel.

Cooling System (External Components)

The H9 depends heavily on good airflow, especially on steep climbs.

Cooling-related catalog parts

1. Radiator ASSY
2. Intercooler ASSY
3. Condenser ASSY
4. Radiator fan assembly
5. Deflectors & cooling air guides (multiple LH/RH options)

Overheating on long hills usually means airflow is restricted—often dust trapped in front cooling stacks.

Doors, Glass & Weatherstrips

 replaced after years of daily use.

Major replacement items

1. Complete door assemblies (FR / RR, LH / RH)
2. Door handles (outer), handle modules, sub-assemblies
3. Pull rods and skeletons for handles
4. Weatherstrips – frame, beltline, door gap, etc.
5. Glass assemblies for all four doors
6. Glass run channels

Typical wear signs

Wind noise at highway speeds often comes from an aging weatherstrip.
A sagging door sometimes traces back to hinge wear on the full door assembly.
Scratched window edges usually mean the glass run channel has hardened.

Tailgate System

The H9 tailgate sees a lot of action—especially in outdoor use.

Replaceable parts

1. Tailgate ASSY
2. Tailgate trim panels
3. Tailgate hinges (upper/lower)
4. Weatherstrip – tailgate frame and door
5. Tailgate lock + hood assemblies

A weak hinge or a worn weatherstrip often causes dust to enter the cabin on dirt roads.

Exterior Body Parts

This section includes most of the parts passengers can see—and many that take the first damage during off-road driving.

Commonly replaced items from the catalog

1. Front grille
2. Radiator grille assembly
3. Front bumper trim / spoiler / brackets
4. Rear bumper trim / brackets / guards
5. Side wall assemblies
6. Fender assemblies (LH/RH)
7. Wheel brow assemblies (FR/RR sections)
8. Roof racks (LH/RH)

A rock strike on gravel can easily crack lower bumper trims or guard boards.

Lighting System

Lighting parts are frequently replaced due to moisture, impacts, or aging.

Replaceable parts

1. Front combination lamps (LH/RH)
2. Rear combination lamps (LH/RH)
3. Fog lamp assemblies (FR & RR)
4. License plate lamps
5. Lamp trims around tail lamps

Fogging lenses usually indicate a compromised seal—replacing the whole assembly gives the best long-term result.

Sensors & Electrical Exterior Modules

Modern SUVs rely heavily on small exterior sensors.

Catalog-included items

1. Front & rear radar sensor brackets
2. Blind spot radar brackets
3. AVM front camera
4. Rearview mirror modules (LH/RH)
5. Various harness brackets and mounting parts

A misaligned radar bracket can cause false alerts or system errors.

Chassis & Underbody Protection

Beyond the drivetrain guards, the catalog also includes:

1. Skid plates
2. Wheelhouse liners
3. Underbody splash shields
4. Rear bumper mounting plates

These protect the SUV’s structure from stones, mud, and water.

Maintenance Tips for HAVAL H9 Owners

Updated to match the new component focus:

1. After off-road trips: check lower guard boards, wheelhouse liners, and radiator fins
2. Every 10,000 km: clean intercooler & condenser surfaces
3. Every long trip: check weatherstrips, especially tailgate seals
4. After minor impacts: inspect bumper brackets and fender edges
5. Seasonal: clean sun-baked roof racks and tighten mounting points

A small crack in a weatherstrip or a loose radiator guide can cause surprisingly big issues later.

Keep Your HAVAL H9 Ready for Any Adventure

Understanding your H9’s key exterior, structural, and engine-bay components makes it easier to avoid costly replacements later.

MotorTec supplies a full range of HAVAL H9 body parts, glass assemblies, lights, cooling components, and underbody protection for 2015–2025 models in our MotorTec Car Parts Catalogue.

FAQ

Q: Does MotorTec supply internal engine or brake parts?

A: The catalog focuses mainly on body, structural, cooling, lighting, and exterior electrical components.

Q: Are the door and tailgate assemblies complete?

A: Yes—front and rear doors, handle modules, glass, and weatherstrips are available.

Q: Can the lighting assemblies be swapped across different H9 years?

A: Many do, but trim-specific versions exist. Always verify part codes before ordering.

For readers who need a complete reference, the full Haval H9 exterior and body parts catalog is listed below: